the 5 speed gearbox has 3 selectors each clamped to 3 steel shafts that slide in the gearbox. 1st and 3rd are selected by one, 2nd and 4th by another and 5th and reverse by the third. It is slightly possible but highly unlikely that the clamping setscrew locking a selector to its selector shaft has come loose allowing that selector to become Ducato 2.8 JTD Timing Belt This all seems very controversial, I too have a 2.8JTD almost 4 years old. The service book states 48 months or 72k miles, rang the local Fiat dealer, and a local Fiat truck dealer they said 5 years or 72k. When I said the record book states 4 year he said I can only tell you what it says on our system. I just bought a 2006 Ducato Maxi with auto transmission. so I would be looking to change oil at the hint of issues. 2006 Fiat Ducato LWB Maxi 2.8 JTD x244 107. Jul 9, 2015. #2. geordie01 said: Hi guys the pressed steel gearbox end cover plate on my 2004 ducato 2.8 is rusted and seems to be leaking oil thru it any one know where I can get a new one from ? thanks. geordie. Do you mean the 5th gear end or the clutch end? Is the leak between the cover and the gearbox? At what intervals should I change the engine oil on my FIAT DUCATO 230 2.8 JTD? FIAT recommends oil change intervals of 15,000 km or 12 months for the DUCATO 230 2.8 JTD Diesel. Outside of these intervals, an oil change may also be necessary if the dashboard oil light comes on. the left hand driveshaft should be:71753965. right hand should be: 71753966. The wheelbearings do go but if its as bad as you say the the hub would be very hot. The vibration in the steering wheel can also be the front wishbone bushes causing the wheels to toe in or out. But more likely the lefthand tripod joint. Fiat Ducato Jtd Gearbox WebHow to change gearbox oil on a Fiat Ducato 2.8 idTD (engine 8140.43) was supposed to change the gearbox oil on my Fiat Ducato 2.8 idTD based Frankia A700 motorhome. I noticed there were a few tips on the net but I couldn't find any guide with pictures showing the reverse switch on top of the gearbox. Points. 54. May 25, 2008. #4. This is for a 2003 Ducato 2.8: The gearchange works with two cables; one for fore/aft and the other left/right. There is a nylon block in the dashboard fitting under the gaiter to which the top ends of the cables are attached, and the other ends go to separate attachment brackets on the gearbox case. bZD3Dit.

fiat ducato 2.8 jtd gearbox oil change